Effects of Different Levels of Black Seed Meal on Laying Hens Performance in Second Production Cycle

پژوهشهای علوم دامی ایران

Article 8, Volume 13, Issue 2 - Serial Number 46, June 2021, Pages 263-273   

Document Type: Research Articles

DOI: 10.22067/ijasr.2022.37122

Authors

Mohammad Reza Ghorbani^{* 1}; ahmad tatar²; Somayyeh Salari³; M.hadi soleymani⁴; Solmaz Khalili Samani⁵

¹Department of Range and watershed Management, Higher Education Complex of Shirvan, Shirvan, Iran and Department of Animal Science, Agricultural Sciences and Natural Resources University of Khuzestan, Ahvaz, Iran

²Animal Science Research Department, Golestan Agricultural and Natural Resources Research and Education Center, AREEO, Gorgan, Iran

³Department of Animal Science, Animal Science and Food Technology Faculty, Agricultural Sciences and Natural Resources University of Khuzestan, Mollasani, Iran

⁴Giah essence company, Gorgan, Iran

⁵Department of Animal Science, Agricultural Sciences and Natural Resources University of Khuzestan, Ahvaz, Iran.

Abstract

Introduction[1] It has been estimated that feed is the major cost associated with commercial poultry production. Conventional plant proteins, such as soybean meal tend to increase the poultry production costs due to limitation in cultivation in some region and therefore, their being transported from other countries. Hence, inclusion of non-conventional feed resource becomes of primary importance in poultry production to maintain the productivity at a lower cost. Black seed (Nigella sativa) referred to an important medical crop in many countries and is primarily consumed as medical oil. Black seed meal (BSM) is by-product after oil removal and can be used as a protein-rich meal (21). Black seed meal contains about 31.75 % crude protein and 19.37 % ether extract and it can be used as good sources of protein and energy (21) and substitution of soybean meal in laying hens practical diets. However, reports on the use of BSM in laying hens diets in second cycle of production are not enough, therefore, in this study, we considered the effect of different levels of black seed meal on laying hens performance in second production cycle.
Materials and Methods This experiment was conducted to determine the fatty acids composition of black seed meal and its effects on performance and egg qualitative traits of laying hens in second production cycle. In the first step, Gas-chromatography was used for determination the fatty acids composition of BSM. In the second step, a total of One hundred and twenty Hy-Line W-36 leghorn hens were housed in cages and randomly allocated to 5 treatment groups for 8 weeks. Each group was divided in to 4 replicates. Feed and water were provided ad libitum. The hens received basal diet (corn and soybean meal based diet with 14.80 % crude protein and 2813 kcal/ kg metabolizable energy) that was formulated to meet the Hy-line W-36 requirements recommended for nutrients. The diet did not have any antibiotics and coccidiostats. Dietary treatments were included 0, 5, 10, 15, and 20 percentage of BSM by expense of Soybean meal in basal diet and clarified as BSM0 (control), BSM5, BSM10, BSM15 and BSM20 respectively. Experiment was designed in a completely randomized design. Egg weight (gr), egg production (%) and egg mass (gr/hen/day) were recorded daily. Feed consumption was measured weekly and feed conversion ratio (FCR) (grams of feed: grams of egg mass) was calculated weekly too. At the end of 2, 4, 6 and 8 weeks of the experiment, two eggs from each replicate were randomly selected for measurement the egg qualitative traits. In this paper laying hens performance factors and egg quality parameters were calculated in three phase, the first 4 weeks, second 4 weeks and total period. Blood serum characteristics were evaluated in the end of experiment by bleeding from laying hens wings.
Results and Discussion The results of this experiment showed that linoleic acid (41.51), oleic acid (34.67 %), palmetic acid (16.12 %), stearic acid (5.59), and linolenic acid (1.97) were the major BSM fatty acids. As it clear, the linoleic acid and oleic acid are most abundant fatty acid (unsaturated) in BSM. Feed intake was decreased by inclusion of BSM in laying hens diet and minimum feed intake was observed in BSM20. It seems to be the bitter taste of black seed meal is responsible for the decline of feed intake. It was reported that BSM has anti-nutritional substance and alkaloids (saponins), that these factors can reduce feed intake when used in high amount in poultry diets (21 and El-Dakhakhny, 1996). Laying hens egg mass was decreased in BSM10, BSM15 and BSM20 groups when compared with control group. Egg mass was calculated by multiplying egg weight in egg production. Reduced of feed intake can affect availability of nutrient for egg production and egg weight, and, therefore, egg mass will be decrease. Scientists reported that BSM can increase laying hens’ body weight and increasing body weight can decrease egg production. Laying hens’ serum cholesterol and triglyceride content were decreased significantly in BSM5 when compared with other groups. It was reported that essential oils in BSM can reduce activity of HMG-CoA (3-hydroxy-3-methylglutaryl coenzyme A) reductase that has vital role in cholesterol synthesis (Crowell, 1999).
Conclusion According to the results of this experiment, using BSM in 5 percent can reduce blood cholesterol and triglyceride without adverse effect on performance parameters.

Keywords

Black seed meal; Egg quality; Laying hen; Performance

References

1. Abbas, T. E. E., and M. E. Ahmed. 2010. Effect of supplementation of Nigella sativa seeds to the broiler chicks’ diet on the performance and carcass quality. International Journal of Agriculture Science, 2 (2): 9-
2. Abd El-Hack, M. E., M. Alagawany, M. Saeed, M. Arif, M. A. Arain, Z. A. Bhutto, and S. A. Fazlani. 2016. Effect of gradual substitution of soybean meal by Nigella sativa meal on growth performance, carcass traits and blood lipid profile of growing Japanese quail. Journal of Animal and Feed Sciences, 25: 244–249.
3. Abdel-Hady, A. A., F. A. Abdel-Azeem, A. A. Abdel-Rafea, and A. G. Gamal. 2009. Effect of replacement of soybean meal protein by Nigella sativa meal protein on performance of growing Japanese quail. Egyptian Poultry Science, 29: 407-422.
4. Abdel-magid, S. S., R. I. EL- Kady, S. M. Gad, and I. M. Awadalla. 2007. Using cheap and local non-conventional protein meal (Nigella sativa) as least cost rations formula on performance of crossbreed calves. International Journal of Agriculture and Biology, 9(6): 877-880.
5. Abdo, Z. M. A. 2004. Effect of phytase supplementation on the utilization of Nigella sativa seed meal in broiler diets. Egyptian Poultry Science, 24: 143-162.
6. AOAC International. 1995. Official Methods of Analyses. 16 ^th AOAC International. Virginia, USA.
7. Aydin, R., M. Karaman, T. Cicek, and H. Yardibi. 2008. Black cumin (Nigella sativa) supplementation into the diet of the laying hen positively influences egg yield parameters, shell quality, and decreases egg cholesterol. Poultry Science, 86: 2590-2595.
8. Badari, O. A., R. A.Taha, A. M. Gamal, and A. C. Abdel-Wahab. 2003. Thymoquinone is a potent superoxide anion scavenger. Drug and Chemical Toxicology, 26: 87–98.
9. Bolukbasi, S.C., O. Kaynar, M. K. Erhan, and H. Uruthan. 2009. Effect of feeding Nigella Sativa oil on laying hen performance, cholesterol and some proteins ratio of egg yolk and Escherichia coli count in faeces. Archiv fur Geflugelkunde, 73: 167-172.
10. Crowell, P. L. 1999. Prevention and therapy of cancer by dietary monoterpenes. Journal of Nutrition, 129: 775-778.
11. Denli, M., F. Okan, and A. N. Uluocak. 2004. Effect of dietary black seed (Nigella sativa) extract supplementation on laying performance and egg quality of quail (Coturnix coturnix japonica). Journal of Applied Animal Research, 26: 73-76.
12. Duncan, D. B. 1955. Multiple range test and multiple F test. Biometrics 11:1-42.
13. Durrani, F. R., N. Chand, K. Zaka, A. Sultan, F. M. Khattak, and Z. Durrani. 2007. Effect of different levels of feed added black seed (Nigella sativa) on the performance of broiler chicks. Pakistan Journal of Biological Science, 10: 4164-4167.
14. El-Bagir, N. Y., R. M. Hama, E. L. Hamed, and A. C. Beynen. 2006. Lipid composition of egg yolk and serum in laying hens fed diets containing black cumin (Nigella Sativa). International Journal of Poultry Science, 5: 574–578.
15. El-Dakhakhny, M. 1996. Studies on the Egyptian Nigella sativa L: IV. Some pharmacological properties of the seeds’ active principle in comparison to its dihydro compound and its polymer. Journal De Pharmacie De Belgique, 15: 1227 –1229.
16. El-Deek, A., A. Saffa, M. Hamdy, and M. M. Khalifah. 1999. Effects of Nigella seed oil meal in broiler diets on performance and physical and sensory characteristics of meat. Egyptian Poultry Science, 22: 207-225.
17. El-Nattat, W.S., and R. I. El-Kady. 2007. Effect of different medicinal plant seeds residues on the nutritional and reproductive performance of adult male rabbits. International Journal of Agriculture and Biology, 9: 479–485.
18. Falahhoseini, H., R. Mohtashami, Z. Sadeghi, Y. Saeidi,and A. Falahhoseini. 2011. Pharmacological effects of black seed (Nigella sativa): A review. Journal of Medical Plants, 38 (2): 1-18. (In Persian).
19. Farahani, J., and A. Ghanbari. 2015. Hy-line W-36 commercial layers management guide. Morghak Co. (In Persian).
20. Jahan, M. S., M. Khairunnesa, S. Afrin, and M. S. Ali, 2015. Dietary black cumin (Nigella sativa) seed meal on growth and meat yield performance of broilers. SAARC Journal of Agriculture, 13(2): 151-160.
21. Matthaus, B., and M. M. Ozcan. 2011. Fatty acids, tocopherol, and sterol contents of some Nigella species seed oil. Czech Journal of Food Science, 29(2): 145-150.
22. Musapur, T., and M. Salarmoeini. 2014. Effect of using different levels of black seed meals on performance and meat quality of Japanese quail. Iranian Journal of Animal Science Research, 6 (1): 17-24. (In Persian).
23. Nascimento, G. A. J., P. B. Rodrigues, R. T. F. Freitas, A. G. Bertechini, R. R. Lima, and L. E. A. Pucci. 2009. Prediction equations to estimate the energy values of plant origin concentrate feeds for poultry utilizing the metaanalysis. Brazilian Journal of Animal Science, 38: 1265–1271.
24. Padmaa, M. P. 2010. Nigella sativa linn A- comprehensive review. Indian Journal of Nutrition, 14: 409- 429.
25. Saeedi, P., S. Tabatabaei, S. Sallary, K. Mirzadeh, and M. Zarei. 2014. Evaluation the effect of black cumin (Nigella Sativa) supplementation in diet on performance and some blood parameters in broiler chickens. Journal of Animal Production, 16 (2): 157-166. (In Persian).
26. SAS Institute INC. 2004. SAS STATs users Guide. Version 9.1, SAS Institute Inc. cary, N.C.
27. Shirzadegan, K., P. Fallahpour, I. Nickkhah, and H. R. Taheri. 2014. Black cumin (Nigella sativa) supplementation in the diet of broilers influences liver weight and its enzymes. Iranian Journal of Applied Animal Science. 5(1): 173-178.
28. Talha, E., E. Abbas, and E. Mohamed. 2010. Effect of supplementation of Nigella sativa seeds to the broiler chick's diet on the performance and carcass quality. International Journal of Agriculture Science, 2(2): 9-13.

Toghyani, M. M., A. Toghyani, G. Gheisari, M. Ghalamkari, and A. Mohammadrezaei. 2010. Growth performance, serum biochemistry and blood hematology of broiler chicks fed different levels of black seed (Nigella sativa) and peppermint (Mentha piperita). Live Science, 129: 173–178.