Evaluation of chemical composition, gas production and digestibility of Lathyrus sativus grain treated using different heat-processing by in vitro and in situ experiments

پژوهشهای علوم دامی ایران

Article 3, Volume 14, Issue 1 - Serial Number 49, March 2022, Pages 27-41   

Document Type: Research Articles

DOI: 10.22067/ijasr.2021.38285.0

Authors

Hossein Rastpoor¹; Seyed Alireza Vakili^{* 2}; Abbas Ali Naserian²; Mohsen Danesh Mesgaran²; Reza Valizadeh²

¹International Campus, Ferdowsi University of Mashhad, Mashhad, Iran.

²Department of Animal Sciences, Faculty of Agriculture, Ferdowsi University of Mashhad, Mashhad, Iran.

Abstract

Introduction Providing the energy and protein in the diet of livestock, due to the high cost of its sources makes the highest cost of feed. Therefore, new and cheap domestic resources should be used in order to reduce costs and independency. Lathyrus sativus as a source of protein has been used in ruminants’ diet and because of similar amino acids profile to soybean meal can be used instead of soybean meal in ruminants’ diet. The protein content of Lathyrus sativus is 25.6-35.9 % of its dray matter. It is also reported that heat-processed soybeans are used as an important source of protein and energy in ruminants because heating reduces the breakdown of protein in the rumen and the passage of essential amino acids into the intestine (5). On the other hand, the reduction of anti-nutrients due to heat treatment, especially extrusion in soybean, has been reported in several studies. There is limited information about the effect of heat-processing on the nutritional value of Lathyrus sativus. The purpose of this experiment was to investigate the chemical composition, anti-nutrients, extent and rate of gas production and protein digestibility of Lathyrus sativus treated with different heat-processing by in vitro and in situ experiments.
Materials and methods The Lathyrus sativus seed were processed by 1) Autoclave at 120 ˚C, 2) Oven at 100 ˚C, 3) Extruding at 110 ˚C, 4) Roasting on direct heat, 5) Furnace at 120 ˚C and 6) Furnace at 200 ˚C. Chemical composition including dry matter, organic matter, crude protein, crude fat, calcium and phosphorus was performed using AOAC methods. Tannin and total phenolic compounds were meseared by Folin and Ciocalteu (12). Extent and rate of gas production were done based on Menk and Stingas. Mobile nylon bag technique was applied for determination of protein digestibility in the romen and intestine. Data were analyzed using GLM procedure of SAS using a completely randomized design with 5 replications.
Results and Discussion Dry matter, ash, crude protein, crude energy, crude fat, calcium and phosphorus were not affected by different processing methods (P <0.05). However the amount of acid detergent fiber (ADF) and natural detergent fiber (NDF) with heat processing methods was significantly lower than non-processing method (P <0.05). Autoclaving and extrusion of Lathyrus sativus reduced the amount of phenolic compounds compared to the control (P <0.05). In addition, the furnace at 120 ° C and roasting even more than autoclaving and extrusion reduced the total phenolic compounds. The amount of gas production during various hours and its rate were significantly affected by the different processing procedures (P<0.05). At the initial hours (2 and 8 h) of incubation, the amount of gas produced in Lathyrus sativus unprocessed and processed in oven 100 ˚C was higher than autoclave 120 ˚C, furnace 120 ˚C, and roasted seeds. Extruded seeds were reduced gas production in initial hours than any other processed methods except those put in the furnace 200 ˚C. The Lathyrus sativus placed in 200 ˚C furnace severely diminished gas production of the incubation at primary hours. The extruded Lathyrus sativus showed higher gas at the 12^th and 24^th hours of incubation compared with primary hours. This trend continued up to the 96^th hour of incubation. The results of gas production had conformity with rumen and intestine digestibility. It seems that the steam pressure in extrude and autoclave process can influence Lathyrus sativus fermentation. This effect in extrude process was higher than autoclave. The rumen and intestine dry matter and protein digestibility in extruded process was higher than the others. Lathyrus sativus with no process, at oven 100 ˚C and furnace 200 ˚C were shown equal dry matter and protein digestibility. The findings of the present research revealed that extruding, autoclaving and roasting procedures lead to increase of dry matter through decreasing water content and that it had no significant effect on other chemical composition. Also, the findings showed that place of Lathyrus sativus in furnace 200 ˚C decreased ADF and NDF Lathyrus sativus which might be due to the removal of some of the shells in this processing. Consequently, the process of extruding, autoclaving and roasting reduced the rapid part degradation of dry matter and protein of Lathyrus sativus and caused the slow part of degradation to increase, which is in consistent to other researcher about increasing of intestine protein digestibility in extruded and roasted soybean seed.
Conclusion Extruded, autoclaved and roasted Lathyrus sativus with the reduction of the amount of ruminal disappearance and the increase of the post ruminal digestibility of dry matter and crude protein transferred the place of the digestion of protein from the rumen to the small intestines. In furnace 200 ˚C, due to the intense denaturation of the protein or the formation of a protein-carbohydrate complex, the digestibility of dry matter and crude protein of Lathyrus sativus in the rumen and intestine was reduced. In addition, the results of our studies in confirming the studies of others reduced the concentration of total tannin and total phenolic compounds in Lathyrus sativus.

Keywords

Gas production; Heat processing; Lathyrus sativus; Rumen and intestine digestibility

References

.Aldrich, C. G., N. R. Merchen, C. M. Parsons, H. S. Hussein, S. Ingram, and J. R. Clodfelter. 1997. Assessment of postruminal amino acid digestibility of roasted and extruded whole soybeans with the precision-fed rooster assay. Journal of Animal Science, 75: 3046–3051.

2.Amirabadi, Z., A. Riasi, H. Janmohammadi, H. Farhangfar, M. H. Fathi Nasri. 2010. The Effect of Raw and Heated Grass Pea (Lathyrus sativus) Seed on Growth Performance and some Blood Metabolites of Broiler Chickens. Animal Science Researches, 20 (4): 53-66. (In Persian).

3.AOAC. 1995. Official methods of analysis. (16th ed). Arlington VA., Association of Official Analytical Chemists.

4.Benchaar, C, and R. Moncoulon. 1993. Effetdel’extrusiona195°C sur la disparition des acides amines du lupin dans le rumen et l’intestin in situ chez lavache. Annales de zootechnie, INRA/EDP Sciences, 42:128–129.

5.Chouinard, P. Y., J. Lévesque, V. Girard, and G. J. Brisson. 1997. Dietary Soybeans Extruded at Different Temperatures: Milk Composition and In Situ Fatty Acid Reactions. Journal of Dairy Science, 80: 2913–2924.

6.Fatahnia, F., S. G. Mosavi, E. Abdi, and A. N. Shokri. 2014. Effect of Roasting and Extruding on Nitrogen Fractions and Ruminal Degradability of Soybean Seed Protein. Research on Animal Production, 5(10): 84-97. (In Persian).

7.Fathi Nasri, M. H. 2005. Impact of the use of raw and heated soybeans on digestive factors, milk production and composition Holstein cows. PhD thesis. Ferdowsi University of Mashhad. (In Persian).

8.Gatel, F. 1994. Protein quality of legume seeds for non-ruminant animals: a literature review. Journal of Animal Feed Science and Technology, 45:317-348.

9.Hanbury, C. D., C. L. White, B. P. Mullan, and K. H. M. Siddique. 2000. A Review of the Potential of Lathyrus sativus L. and Lathyrus Cicera L. Grain for use as Animal Feed. Journal of Animal Feed Science and Technology, 87: 1-27.

10.Khorasani, H., M. Bashtani, A. Forughi, H. FarhangFar, and F. Ganji. 2020. Effects of roasting and extruding heat processes on chemical composition, degradability fractions and intestinal digestibility of dry matter and crude protein of whole soybeans. Iranian Journal of Animal Science Research, 11 (4): 399-412.

11.Low, R. K. C., R. G. Rotter, R. R. Marquardt, and C. G. Campbell. 1990. Use of Lathyrus sativus L. (var. Seminis albi) as a foodstuff for poultry. Journal of British Poultry Science, 31:615-625.

12.Makkar, H. P. S. 2005. In vitro Gas Methods for Evaluation of Feeds Containing Phytochemicals. Animal Feed Science and Technology, 123: 365-377.

13.Mccann, M. E. E., E. Newell, C. Preston, and K. Forbes. 2006. The use of mannan oligosacharides and/or tannin in broiler diets. International Journal of Poultry Science, 5(9): 873-879.

14.Mehrez, A. Z., and E. R. Orskov. 1977. A study of artificial fiber bag technique for determining the digestibility offeeds in the rumen. Journal of Agriculture Science, 88: 645–650.

15.Menke, H. H., and H.  Steingass. 1988. Estimation of the energetic feed value obtained from chemical analysis and in vitro gas production using rumen fluid. Animal Research Development, 28: 7-55.

16.Noeroozi Deyarjan1, M., A. Assadi-Alamouti, A. Afzalzadeh, and M. Danesh Mesgaran. 2017. Effects of replacing soybean meal with heat-treated soybean meal in diets varying in crude preotien content on performance of dairy cows under mild heat stress. Journal of Animal Production, 19: 4. 751-763.

17.Nowak, W., S. Michalak, and S. Wylegala. 2005. In situ evaluation of ruminal degradability and intestinal digestibility of extruded soybeans. Czech. Journal of Animal Science, 50: 281–287.

18.Orskov, E. R., and I. McDonald. 1979. The estimation of protein degradability in the rumen from incubation measurements weighed according to rate of passage. Journal of Agriculture Science, 92: 499-503.

19.Owens, F. N., D. S. Secrist, W. J. Hill, and D. R. Gill. 1997. The effect of grain source and grain processing on performance of feedlot cattle. A review. Journal of Animal Science, 75:868-879.

20.Peng, H. H. and Brooker, J. D. 2000. Isolation of ODAP-degrading Bacteria from the Sheep Rumen. Lathyrus Lathyrism Newsletter, 1: 33.

21.Ramachandran, S., and A. K. Ray. 2008. Effect of Different Processing Techniques on the Nutritive Value of Grass Pea, Lathyrus sativus L., Seed Meal in Compound Diets for Indian Major Carp Rohu, Labeo Rohita (Hamilton), Fingerling. Archives of Polish Fisheries, 16: 189-202.

22.Razm-Azar, V., N. M. Torbatinejad, J. Seifdavati, and S. Hassani. 2012. Evaluation of chemical characteristics, rumen fermentation and digestibility of Vicia sativa, Lathyrus sativus and Vicia ervilia grain by in vitro methods. Journal of Animal Science Researches, 22(2):107-119. (In Persian).

23.Reddy, P. V., J. L. Morrill, and L. S. Bates. 1993. Effect of roasting temperatures on soybean utilization by young dairy calves. Journal of Dairy Science, 76: 1387–1393.

24.Reynal, S., and G. Broderick. 2005. Effect of dietary level of rumen-degraded protein on production and nitrogen metabolism in lactating dairy cows. Journal of Dairy Science, 88: 4045-4064.

25.Riasi, A., M. Golizadeh, M. H. Fathi, N. Asadzadeh, and A. Taghizadeh. 2014. Determination of the Nutritive Value of Unheated vs. Heat Processed Grass Pea Seed in Ruminants. Journal of Agricultural Science and Technology, 16: 527-536.

26.Sadeghi, A. A., A. Nikkhah, and P. Shawrang. 2005. Effects of heat processing on ruminal protein degradation of soybean meal. Journal of Agricultural Sciences, 11(3): 189-200.

27.SAS, 2003. Version 9.1. SAS Institute Inc., Cary, NC.

28.Sharma, A., M. Kalia, and S. R. Malhotra. 2003. Effect of antinuritional factors in Khesari seeds (Lathyrus sativus) on the biological performance of chickens. Lathyrus Lathyrism, 3: 1-3.

29.Stern, M. D., K. A. Santos, and L. D. Satter. 1985. Protein degradation in rumen and amino acid absorption in small intestine of lactating dairy cattle fed heat-treated whole soybeans. Journal of Dairy Science, 68: 45–56.

30.Tadelle, D., Y. Alemu, D. Nigusie, and K. J. Peters. 2003. Evaluation of Processing Methods on the Feeding Value of Grass Pea to Broilers. International Journal of Poultry Science, 2(2): 120- 127.

31.Tahan, G., M. H. Fathi Nasri, A. Riasi, M. Behgar, and H. Farhangfar. 2012. The effect of electron irradiation on the parameters of degradability and ruminal and post-ruminal digestibility of dry matter and crude protein of some plant protein sources. Iranian Journal of Animal Science Research, 3(4): 422-434.

32.Van Soest, P. V., J. B. Robertson, and B. A. Lewis. 1991. Methods for dietary fiber, neutral detergent fiber, and non-starch polysaccharides in relation to animal nutrition. Journal of Dairy Science, 74:3583-3597.

33.Yan, Z. Y., P. S. Spender,, Z. X, Li,, Y. M. Liang,., Y. F. Wang,, C. Y. Wang,., and F. M. Li. 2006. Lathyrus sativus (grass pea) and its neurotoxin ODAP. Phytochemistry, 67: 107-121.

34.ZeidAli-Nejad, A., G. R. Ghorbani, S. Kargar, A. Sadeghi-Sefidmazgi, A. Pezeshki, and M. H. Ghaffari. 2018. Nutrient intake, rumen fermentation and growth performance of dairy calves fed extruded full-fat soybean as a replacement for soybean meal. Animal, 12(4): 733-740.