An Investigation into Separation of Impurity from Saffron Stigma Using an Electrostatic Separator

ماشین های کشاورزی

Article 5, Volume 5, Issue 1 - Serial Number 9, 2015, Pages 44-51   

Document Type: Research Article

DOI: 10.22067/jam.v5i1.24900

Authors

H. Mortezapour^{* 1}; S. Moshiri Rad²; M. Akhbari³

¹Shahid Bahonar University of Kerman

²Mashhad University of Medical Science

³Birjand University of Medical Science

Abstract

In the present study, a laboratory electrostatic separator was constructed and its separation potential of white saffron impurities from stigma was investigated. The device was comprised of a nylon ribbon which moves in contact with a woolen brush and was charged by the triboelectric effect. The charged ribbon, then, moved over the material pan. Since the electrostatic behavior vary from various materials, their attraction to the ribbon differ. The separation tests were conducted at three levels of ribbon position (with 1.5, 2.5 and 3.5 cm from the material pan), three drum speeds (50, 60 and 70 rpm) and three working times (120, 18 and 240 seconds). The results showed that material absorption increased as working time increased and the ribbon distance decreased. Meanwhile, rising the speed from 50 to 60 rpm improved material absorption while, more increasing from 60 to 70 rpm reduced the absorption. A maximum impurity separation of 97% was observed with ribbon distance of 1.5 cm, ribbon speed of 60 rpm and working for 240 seconds. The minimum stigma losses were found to be about 2% when the ribbon distance and speed were 3.5 cm and 70 rpm, respectively, and the separator worked for 120 seconds.

Keywords

Electrostatic; Saffron; separation

References

1. Cao, Q., X. Xie, J. Li, J. Dong, and L. Jin. 2012. A novel method for removing quinoline insolubles and ash in coal tar pitch using electrostatic fields. Fuel 96: 314-318.

2. Das, I., S. Das, and T. Saha. 2010. Saffron suppresses oxidative stress in DMBA-induced skin carcinoma: A histopathological study. Acta Histochemica 112: 317-327.

3. Dwari, R. K., and K. Hanumantha Rao. 2006. Tribo-electrostatic behaviour of high ash non-coking Indian thermal coal. International Journal of Mineral Processing 81: 93-104.

4. Dwari, R. K., and K. Hanumantha Rao. 2008. Non-coking coal preparation by novel tribo-electrostatic method. Fuel 87: 3562-3571.

5. Dwari, R. K., and K. Hanumantha Rao. 2009. Fine coal preparation using novel tribo-electrostatic separator. Minerals Engineering 22: 119-127.

6. Eskibalci, M. F., and S. G. Ozkan. 2012. An investigation of effect of microwave energy on electrostatic separation of colemanite and ulexite. Minerals Engineering 31: 90-97.

7. Guo, C., H. Wang, W. Liang, J. Fu, and X. Yi. 2011. Liberation characteristic and physical separation of printed circuit board (PCB). Waste Management 31: 2161-2166.

8. Hemery, Y., U. Holopainen, A. M. Lampi, P. Lehtinen, T. Nurmi, V. Piironen, M. Edelmann, and X. Rouau. 2011. Potential of dry fractionation of wheat bran for the development of food ingredients, part II: Electrostatic separation of particles. Journal of Cereal Science 53: 9-18.

9. Jiang, W., L. Jia, and X. Zhen-ming. 2009. A new two-roll electrostatic separator for recycling of metals and nonmetals from waste printed circuit board. Journal of Hazardous Materials 161: 257-262.

10. Juan, J. A. D., H. L. Corcoles, R. M. Mu˜noz, and M. R. Picornell. 2009. Yield and yield components of saffron under different cropping systems. Industrial Crops and Products 30: 212-219.

11. Kanakis, C. D., P. A. Tarantilis, C. Pappas, J. Bariyanga, H. A. Tajmir-Riahi, and M. G. Polissiou. 2009. An overview of structural features of DNA and RNA complexes with saffron compounds: Models and antioxidant activity. Journal of Photochemistry and Photobiology B: Biology 95: 204-212.

12. Kawamoto, H. 2008. Some techniques on electrostatic separation of particle size utilizing electrostatic traveling-wave field. Journal of Electrostatics 66: 220-228.

13. Li, J., H. Lu, S. Liu, and Z. Xu. 2008. Optimizing the operating parameters of corona electrostatic separation for recycling waste scraped printed circuit boards by computer simulation of electric field. Journal of hazardous materials 153: 269-275.

14. Papandreou, M. A., M. Tsachaki, S. Efthimiopoulos, P. Cordopatis, F. N. Lamari, and M. Margarity. 2011. Memory enhancing effects of saffron in aged mice are correlated with antioxidant protection. Behavioural Brain Research 219: 197-204.

15. Saeki, M. 2008. Triboelectric separation of three-component plastic mixture. Particulate Science and Technology 26: 494-506.

16. Shamsa, A., H. Hosseinzadeh, M. Molaei, M. T. Shakeri, and O. Rajabi. 2009. Evaluation of Crocus sativus L. (saffron) on male erectile dysfunction: A pilot study. Phytomedicine 16: 690-693.

17. Tilmatine, A., S. Bendimerad, M. Younes, and L. Dascalescu. 2009. Experimental analysis and optimisation of a free-fall triboelectric separator of granular plastic particles. International Journal of Sustainable Engineering 2: 184-191.

18. Vlad, S., M. Mihailescu, D. Rafiroiu, A. Iuga, and L. Dascalescu. 2000. Numerical analysis of the electric field in plate-type electrostatic separators. Journal of Electrostatics 48: 217-229.

19. Wu, J., J. Li, and Z. Xu. 2008. Electrostatic separation for multi-size granule of crushed printed circuit board waste using two-roll separator. Journal of Hazardous Materials 159: 230-234.

20. Wu, J., Y. Qin, Q. Zhou, and Z. Xu. 2009. Impact of nonconductive powder on electrostatic separation for recycling crushed waste printed circuit board. Journal of Hazardous Materials 164: 1352-1358.

21. Yanar, D. K., and B. A. Kwetkus. 1995. Electrostatic separation of polymer powders. Journal of Electrostatics 35: 257-266.