Removal of Petroleum Hydrocarbons from Contaminated Waters Using a Solar Photocatalytic Process

مهندسی عمران فردوسی

Article 3, Volume 29, Issue 1 - Serial Number 18, July 2017, Pages 37-48   

Document Type: پژوهشی

DOI: 10.22067/civil.v29i1.42661

Authors

Fattah Soroush; Hossein Ganjidoust^* ; Bita Ayati

Tarbiat Modares Univ.

Abstract

Removal of petroleum hydrocarbons from synthetic contaminated water using with photocatalytic process was conducted in the presence of nano TiO2 immobilized on the concrete plates. The solar photoreactor was consisted of storage tank of 60 L with floating pump, cascade system with 5 concrete steps, a 5 L weir on the top of the stairs and metalic chassis. The UV-A radiation of the sunlight was used instead of UV-A lamps as the irradiation source. The optimum parameters were pH of 5, TiO2 mass loading of 60 grm-2, UV equivalent irradiation time of 200 min, initial concentration of 100 mgL-1 and H2O2 concentration of 2000 mgL-1.The results demonstrated that under optimal conditions removal efficiency of chemical oxygen demand (COD), total petroleum hydrocarbons (TPH) and poly aromatic hydrocarbons (PAHs) were 70.48%, 67.63 % and 84.75% respectively. Also the results of GC-FID analysis indicated that most of PAHs were eliminated and only non-toxic aliphatic hydrocarbons were remained.

Keywords

Solar photoreactor; TiO2; Light-Weighted Concrete; TPH; PAH; COD

Supplementary Files

3.pdf

References

1. Stepnowski, P., Siedlecka, E. M., Behrend, P., Jastorff, B, "Enhanced photo-degradation of contaminants in petroleum refinery wastewater", Water Research, Vol. 36, pp. 288-294, (2002).

2. Diya Uddeen, B., Wan Daud, W., Abdul Aziz, A., "Treatment technologies for petroleum refinery effluents: A review", Process Safety and Enviromental Protection, Vol. 89, pp. 95-105, (2011).

3. Sun, Y., Zhang, Y., Quan, X., "Treatment of petroleum refinery wastewater by microwave-assisted catalytic wet air oxidation under low temperature and low pressure", Seperation and Purification Technology, Vol. 62, pp. 565-570, (2008).

4. Ahmadun, F-R., Pendashteh, A. R., Abdullah, L. C., Madan, S. S i., and Abidin, Z. Z., "Review of technologies for oil and gas produced water treatment", Journal of Hazardous Materials, Vol. 170, pp. 530-551, (2009).

5. Ghidossi, R., Veyret, D., Scotto., Jalabert, T., Moulin, P., "Ferry oily wastewater treatment", Seperation and Purification Technology,Vol. 64, pp. 296-303, (2009).

6. Adam, P., Roger, M. R., "Treatment of tunnel wash waters- experiments with organic sorbent materials. Part I: Removal of polycyclic aromatic hydrocarbons and nonpolar oil", Journal of Enviromental Science, Vol. 20, pp. 964-969, (2008).

7. Azin, R, "Gulf oil pollution", Bushehr University of Medical Sciences and Health Services Publisher (2009).

8. Bastani, D., Safekordi, A. A., Alihosseini, A., Taghikhani, V., "Study of oil sorption by expanded perlite at 298.15 K", Seperation and Purification Technology, Vol. 52, pp. 295-300, (2006).

9. Cha, Zh., Lin, C. F., Cheng, Ch., Hong, P., "Removal of oil and oil sheen from produced water by pressure-assisted ozonation and sand filtration", Chemosphere, Vol. 78, pp. 583-590, (2010).

10. Rezaei Hosein Abadi, S., Sebzari, M. R., Hemati, M., Rekabdar, F., "Ceramic membrane performance in M.F. of oily wastewater", Desalination, Vol. 265, pp, 222-228, (2011).

11. Diya Uddeen, B., Wan Daud, W., Abdul Aziz, A., "Treatment technologies for petroleum refinery effluents", Process Safety and Enviromental Protection,Vol. 89, pp. 95-105, (2011).

12. Moussavi, Gh., Khosravi, R., Farzadkia, M., "Removal of petroleum hydrocarbons from contaminated groundwater using an electrocoagulation process: Batch and continuous experiments", Desalination, Vol. 278, pp. 288-294, (2011).

13. Shpiner, R., Liu, G., Stuckey, D. C., "Treatment of oilfield produced water by waste stabilization ponds: Biodegradation of petroleum-derived materials", Bioresource Technology, Vol. 100, pp. 6229-6235, (2009).

14. Rastegar, S. O., Mousavi, S. M., Shojaosadati., Sheibani, S., "Optimization of petroleum refinary effluent treatment in a UASB reactor using response surface methodology", Journal of Hazardous Materials, Vol. 197, pp. 26-32, (2011).

15. Malato, S., Fernandez-Ibanez, P., Maldonado, M. I., Blanco, J., Gernjak, W., "Decontamination and disinfection of water by solar photocatalysis: Recent overview and trends", Catalysis Today,Vol, 147, pp. 1-5 (2009).

16. Ghaly, M. Y., Jamil, T. S., El-Seesy, I. E., Souaya, E. R., Nasr, R., "Treatment of highly polluted paper mill wastewater by solar photocatalytic oxidation with synthesized nanoTiO2", Chemical Engineering Journal, Vol. 168, pp. 446-454, (2011).

17. Monteagudo, J., Duran, A., Guerra, j., Coca, P., "Solar TiO2 photocatalytic degradation of IGCC power station effluents using a Fresnel lens", Chemosphere, Vol. 71, pp. 161-167, (2008).

18. Zayani, Gh., Bousselmi, L., Mhenni, F., Ghrabi, A., "Solar photocatalytic degradation of commercial textile azo dyes: Performance of pilot plant scale thin film fixed-bed reactor", Desalination, Vol. 246, pp. 344-352, (2009).

19. Neti Rao, N., Chaturvedi, V., Li Puma, G., "Novel pebble bed photocatalytic reactor for solar treatment of texile wastewater", Chemical Engineering Journal, Vol. 184, pp. 90-97, (2012).

20. American Society for Testing and Materials (ASTM) D 7063. Standard test method for effective porosity and effective air voids of compacted bituminous paving mixture samples, Volume 03-04, Philadelphia, USA, (2005).

21. Delnavaz, M., Ayati, B., Ganjidoust, H., Sanjabi, S., "Optimization of Photo-Catalytic Process by TiO2 Nano Powder Immobilized on Concrete Surface for Treatment of Phenolic Wastewater", Environmental Engineering and Management Journal, Vol. 10, No. 10, pp. 1459- 1466, (2010).

22. American Society for Testing and Materials (ASTM) D 7066-04. Standard test method for dimer/trimer chlorotrifluoroethylene (S-316) Recoverable Oil and Grease and Nonpolar Material by Infrared Determination, Vol. 03-04, Philadelphia, USA, (2005).

23. EPA. "Test Method 8100: Polynuclear Aromatic Hydrocarbons", USA.

24. APHA, "Standard Methods for Examination of Water and Wastewaters", American Public Health Association, Washington DC, (2005).

25. Saien, J., Nejati, H., "Enhanced photocatalytic degradation of pollutants in petroleum refinery wastewater under mild conditions", Journal of Hazardous Materials, Vol. 148, pp. 491- 495, (2007).

26. Shahrezaei, F., Mansouri, Y., Lorestani, Zinatizadeh, A. A., Akbari, A., "Process modeling and kinetic evaluation of petroleum refinery wastewater treatment in a photocatalytic reactor using TiO2 nanoparticles", Powder Technology, Vol. 221, pp. 203-212, (2012).