Study on the effect of osmotic pretreatment on the quality of air-dried potato sticks using response surface methodology

مجله پژوهشهای علوم و صنایع غذایی ایران

Article 10, Volume 15, Issue 2 - Serial Number 56, May and June 2019, Pages 355-367   

Document Type: Research Article

DOI: 10.22067/ifstrj.v15i2.72319

Authors

Nahid Jafari¹; Seyed Hamidreza Ziaolhagh^{* 2}; Abdorreza Mohammadi Nafchi³

¹Department of Food Science and Technology, Damghan Branch, Islamic Azad University, Damghan, Iran.

²Agricultural Engineering Research Department, Semnan (Shahrood) Agricultural and Natural Resources Research and Education Center, AREEO, Shahrood, Iran.

³Food & Chemical Engineering Department, Islamic Azad University, Damghan, Iran.

Abstract

Introduction: Potato is the fourth most important agricultural product after rice, wheat, and corn. Potato produces more dry matter, protein, and minerals per unit area in comparison with other crops. Many of the ingredients in potato are important, due to their beneficial effects on health. Hence, this product is very suitable for human consumption. Osmotic dehydration is used to remove a portion of water from foods such as fruits and vegetables, by immersion in high osmotic solutions such as sugars and salts.  Osmotic dehydration is a relatively simple and economical process that improves the texture and rehydration properties of the products and prevents enzymatic browning by preventing the activity of polyphenol oxidases. In this process, the acid is removed and the sugar is absorbed, thus the composition of the fruits is changed and the taste and total acceptance of the product are improved. Osmotic dehydrating method has been used for drying various products such as carrots, mangoes, pineapples, strawberries, bananas, apples, apricots, and many other fruits. In this research, the effects of osmotic pre-treatment on qualitative and sensory properties of dried potatoes were investigated.
 Materials and methods: In this study, Agria cv. potato samples were used and after washing, were completely peeled and cut into pieces of 3.5 × 0.5 × 0.5 cm. The treatments used in this study included osmotic solution concentration (at 0, 10 and 20% sodium chloride levels), osmotic solution temperature (30, 45 and 60°C), and immersion time in osmotic solution (at three levels 60, 240 and 720 minutes). The proportion of potato sticks to osmotic solution in all experiments was 1:6. After applying osmotic pre-treatment, samples were dried in an oven with a temperature of 60°C and a flow rate of 1.5 m/s to reach a moisture content of 8-10%. The moisture content, rehydration capacity, shrinkage, browning, color indices, and sensory properties (taste, color, shape, strength, and total acceptance) of potato samples were evaluated after the drying process and the response surface methodology (RSM) based on central composite design (CCD) were used to determine the optimal conditions for osmotic pre-treatment.
 Results and discussion: The results of statistical analysis of the data showed that osmotic time and osmotic solution concentration had a significant effect on moisture content of potato slices. By increasing the time and decreasing the concentration of osmotic solution, moisture content of dried potato samples increased. The immersion time and osmotic solution temperature did not have any significant effect on the rehydration of potato slices, but the effect of osmotic solution’s concentration was statistically significant. By increasing the concentration of osmotic solution, the rehydration rate of potato samples decreased. The results showed that the interaction of temperature and concentration of osmotic solution had a significant effect on the degree of shrinkage of potato slices. Osmotic time and osmotic solution concentration had statistically significant effects on the browning index of potato slices, in a way that by increasing the concentration of osmotic solution, the browning index of potato samples decreased initially and then increased. The results of statistical analysis of the color indices showed that the osmotic solution temperature had a significant effect on the brightness (L*) of the potato slices, while the concentration of osmotic solution significantly affected their yellowness (b*) and the temperature and concentration of osmotic solution had a significant effect on the redness (a*) of the potato slices. By increasing the concentration of osmotic solution, the overall change in the color (E) of potato samples at high temperatures of osmotic solution first increased and then decreased. Sensory evaluation results showed that concentration, time, and temperature of osmotic solution had no significant effect on the sensory properties of potato sticks, except for taste. By increasing the temperature and time of immersion in osmotic solution, the taste scores of the samples increased.  According to the results of optimization by the surface response method, the concentration of 2%, temperature of 46° C and dipping time of 173 min was introduced as favorable conditions. 

Keywords

air drying; dried foods; Osmotic Dehydration; potato products

References

Alakali, J.S., Ariahu, C.C., Kpa, N.N. 2006. Kinetics of osmotic dehydration of mango. Journal of Food Processing and Preservation, 30: 597-607

AOAC. 1995. Official Methods of Analysis: Official Method for Moisture. Method No. 925.10. Association of Official Analytical Chemists, Washington DC.

Bakalis, S. and Karathanos, VT. 2005. Study of rehydration of osmotically pretreated dried fruit samples. Drying Technology, 23: 533-549.

Chavan, U.D. Amarowicz., R. 2012. Osmotic Dehydration Process for Preservation of Fruits and Vegetables. Journal of Food Research, 1(2): 201-209.

Fathi, M., Mohebbi, M. and Razavi, S. M. A. 2011. Application of image analysis and artificial neural network to predict mass transfer kinetics and color changes of osmotically dehydrated kiwifruit. Food and Bioprocess Technology, 4: 1357-1366.

Fellows, P. and Hampton, A. 1992. Small-Scale Food Processing. A Guide to Appropriate Equipment. Intermediate Technology Publications, London, 7: 155-156.

Figiel, A. 2010. Drying kinetics and quality of beetroots dehydrated by combination of convective and vacuum-microwave methods. Journal of Food Engineering, (98): 461-470.

Friedman, M. 1997. Chemistry, biochemistry, and dietary role of potato polyphenols. A review. Journal of Agricultural and Food Chemistry, 45: 1523–1540.

Ispir, A., Togrul, T.I. 2009. Osmotic dehydration of apricot: Kinetics and the effect of process parameters. Chemical Engineering Research and Design, 78: 166-180.

Katan, M. B., De Roos, N. M. 2004. Promises and problems of functional foods. Critical Reviews in Food Science and Nutrition, 44: 369–377.

Koc, B., Eren, I., and Ertekin, F.K. 2008. Modelling bulk density, porosity and shrinkage of quince during drying: The effect of drying method. Journal of Food Engineering, (85): 340-349.

Kolawole, O.M., Adeyemi, B.J., Kayode, R.M.O. and Ajibola, T.B. 2009. The Drying Effect of Colour Light Frequencies on the Nutrient and Microbial Composition of Cassava. African Journal of Agricultural Research, 4: 171-177.

Matusek, A., Czukor, B., Meresz, P. 2008. Comparison of sucrose and fructo-oligosaccharides as osmotic agents in apple. Innovative Food Science and Emerging Technologies, 9: 365-373.

Pandharipande, S.L., Saurav, P., Ankit, S.S. 2012. “Modeling of Osmotic Dehydration Kinetics of Banana Slices using Artificial Neural Network. International Journal of Computer Applications, 48 (3): 26-31.

Panyawong, S. and Devahastin, S. 2007. Determination of deformation of a food product undergoing different drying methods and conditions via evolution of a shape factor. Journal of Food Engineering, (78): 151-161.

Piotrowski, D., Lenart, A., Wardzyński, A. 2004. Influence of osmotic dehydration on microwave-convective drying of frozen strawber‌ries. Journal of Food Engineering, 65: 519-25.

Rahman, M.S., Lamb, L. 1990. Osmotic dehydration of pineapple. Journal of Food Science and Technology, 27: 150-152.

Rahman, M.S. 2007. Drying and Food Preservation, In Rahman MS, Handbook of food preservation. 2nd ed, CRC press, 412.

Raoult-Wack, AL. 1994. Recent advances in the osmotic dehydration of foods. Trends of Food Science and Technology, 5: 255-260.

Rastogi, N.K., Nayak, C.A. and Raghavarao, K. 2004. Influence of osmotic pre-treatments on rehydration characteristics of carrots. Journal of Food Engineering, 65(2): 287-292.

Shakouri, S., Ziaolhagh, H.R., Sharifi-Rad, J., Heydari-Majd, M., Tajali, R., Nezarat, S. and Da Silva, J.A.T., 2015. The effect of packaging material and storage period on microwave-dried potato (Solanum tuberosum L.) cubes. Journal of food science and technology, 52(6), pp.3899-3910.

Shi, J.J. 2008. Osmotic Dehydration of Foods,” Food Drying Science and Technology: Microbiology, Chemistry, Applications, DEStech Publications, Inc. Pennsylvania, U. S. A 275-295.

Singh, B., Panesar, S., Gupta, A.K. and Kennedy, F. 2006. Optimization of osmotic dehydration of carrot cubes in sucrose-salt solutions using response methodology. European Food Research and Technology, 225: 157-165.

Tiwari, R. B., Jalali, S. 2004. Studies on osmtic dehydration of different varieties of mango. In proceeding of First Indian Horticulture congress-2004, New Delhi.

Tkalcic, M. and Tasic, J.F., 2003. Colour spaces: perceptual, historical and applicational background (Vol. 1, pp. 304-308). IEEE.

Torres, J.D., Talens, P., Escriche, I.A. 2012. Chiralt Influence of process conditions on mechanical properties of osmotically dehydrated mango. Journal of Food Engineering, 4: 240-246.

Ziaolhagh, S. H. R. (1999). Investigation on the quality and shelf life of raisin and dried apricots in different export packages. M.Sc.Thesis. Ferdowsi University of Mashhad.