Increasing the Production of Carotenoids in Chlorella sorokiniana IG-W-96 by Changing the Concentration of Nutrients and Phytohormones

مجله پژوهشهای علوم و صنایع غذایی ایران

Article 7, Volume 19, Issue 5 - Serial Number 83, November and December 2023, Pages 663-673   

Document Type: Research Article

DOI: 10.22067/ifstrj.2022.79014.1209

Authors

Zohre Noruzi Motlagh; Mahmoud A. Mahdavi^* ; Reza Gheshlaghi

Department of Chemical Engineering, Faculty of Engineering, Ferdowsi University of Mashhad, Mashhad, Iran

Abstract

Introduction
 Carotenoids have many effects on human health. These compounds are produced by plants and microalgae. The extraction of carotenoids from microalgae such as Chlorella has received much attention, since microalgae grow all year round (regardless of the season) and at a much faster rate than plants in non-arable lands. The aim of this research was to optimize the concentrations of nutrients (nitrogen and phosphorous) in the growth medium of microalgae with the objective of maximizing carotenoids content. At the optimized nutrient conditions, the effect of phytohormones on production of carotenoids using Chlorella sorokiniana IG-W-96 was investigated.
 
Materials and Methods
Chlorella sorokiniana IG-W-96 was cultivated in BG11 growth medium with light intensity of 25000 lux and light: dark cycle of 16: 8 supplied with compressed air flow of 0.5 vvm containing 6% vol carbon dioxide. Under three concentrations of nitrate (0.04, 0.25, 1.5 ) and three concentrations of phophate (0.01, 0.04, 0.16 ) and carotenoid concentration was measured. Full factorial experimnetal design was performed and the resuts of the experiments were analyzed using Minitab (ver. 21.01.1). Finally, the best concentrations of nitrate and phosphate were chosen for pigments production, and at that concentration, naphthalene acetic acid (0, 2.5, 5, 7.5, 10 and 12 ppm) was added to the culture medium to check its effect on pigments production. By measuring the dry weight of C. sorokiniana, its growth rate was determined. After extracting the pigments with solvent, the concentration of the pigments was determined by measuring the amount of light absorption.
 
Results and Discussion
Dry weight
The results showed that the highest amount of dry weight was related to the treatment with nitrate amount of 0.25 , and nitrate more and less than this amount caused a decrease in growth. This result was not dependent on the amount of phosphate and was true for all phosphate concentrations. Nitrate reduction from 1.5 to 0.25 increased the growth of microalgae up to 81.8%, so that the dry weight of 0.88  reached 1.6 . However,  reduction of nitrate from 0.25 to 0.04  decreased the dry weight by 65.6%. In order to reach the maximum growth rate, it is necessary to determine the appropriate concentration of each nutrient.
 
Carotenoids
Unlike the dry weight, not only the pigment production did not decrease with the excessive of nitrate concentration, but also the maximum amount of pigment production was related to the treatment with the maximum amount of nitrate concentration. Based on the results obtained, the concentration of carotenoids was higher in the concentration of 1.5  of nitrate and 0.04  of phosphate (6.7 ).
When the nitrate concentration was very low (0.04 ), changing the phosphate concentration had no significant effect on the production rate of any of the pigments. Only when the nitrate concentration was high (1.5 ), change in phosphate concentration caused a change in pigments concentration. The increase of phosphate concentration from 0.01 to 0.04 increased the carotenoids concentration to 1.65-fold. Of course, increasing phosphate concentration to 0.16 did not affect the pigments concentration.
 Based on the statistical analysis, the P-value<0.05 indicated that the effect of the factors and the model was significant. In this situation, in order to increase the production of carotenoids, naphthalene acetic acid was added to the phytohormone culture medium. At the optimal concentration of 2.5 ppm of naphthalene acetic acid, the concentration of carotenoids increased by 26.71% and reached 8.49 . However, phytohormone had no significant effect on dry weight.
 
Conclusion
Carotenoid production using microalgae could be maximized through optimization of nutrients concentrations (nitrate and phosphate) in the growth medium. Phytohormones could further increase the prodcution of carotenoids at optimum concnetrations.
 

Keywords

C. sorokiniana; Nitrate; Phosphate; Pigment

References

1. Dammak, , Hadrich, B., Miladi, R., Barkallah, M., Hentati, F., Hachicha, R., Laroche, C., Michaud, P., Fendri, I. & Abdelkafi, S. (2017). Effects of nutritional conditions on growth and biochemical composition of Tetraselmis sp. Lipids in Health and Disease, 16(1), 1-13. https://doi.org//10.1186/s12944-016-0378-1
2. Dao, -H., Wu, G.-X., Wang, X.-X., Zhuang, L.-L., Zhang, T.-Y. & Hu, H.-Y. (2018). Enhanced growth and fatty acid accumulation of microalgae Scenedesmus sp. LX1 by two types of auxin. Bioresource Technology, 247, 561-567. https://doi.org/10.1016/j.biortech.2017.09.079
3. Fu, , Cui, X., Li, Y., Xu, L., Zhang, C., Xiong, R., Zhou D. & Crittenden, J.C. (2017). Excessive phosphorus enhances Chlorella regularis lipid production under nitrogen starvation stress during glucose heterotrophic cultivation.Chemical Engineering Journal, 330, 566-572. https://doi.org/10.1016/j.cej.2017.07.182
4. George, , Pancha, I., Desai, C., Chokshi, K., Paliwal, C., Ghosh, T. & Mishra, S. (2014). Effects of different media composition, light intensity and photoperiod on morphology and physiology of freshwater microalgae Ankistrodesmus falcatus–A potential strain for bio-fuel production. Bioresource Technology, 171, 367-374. https://doi.org/10.1016/j.biortech.2014.08.086
5. Guldhe, , Renuka, N., Singh P., & Bux, F. (2019). Effect of phytohormones from different classes on gene expression of Chlorella sorokiniana under nitrogen limitation for enhanced biomass and lipid production. Algal Research, 40, 101518. https://doi.org/10.1016/j.algal.2019.101518
6. Huang, , Marchand, J., Thiriet-Rupert, S., Carrier, G., Saint-Jean, B., Lukomska, E., Moreau, B., Morant-Manceau, A., Bougaran, G., & Mimouni, V. (2019). Betaine lipid and neutral lipid production under nitrogen or phosphorus limitation in the marine microalga Tisochrysis lutea (Haptophyta). Algal Research, 40, 101-506. https://doi.org/10.1016 /j.algal.2019.101506
7. Ju, -H., Ko, D.-J., Heo, S.-Y., Lee, J.-J., Kim, Y.-M., Lee, B.-S., Kim, M.-S., Kim, C.-H., Seo, J.-W., & Oh, B.-R. (2020). Regulation of lipid accumulation using nitrogen for microalgae lipid production in Schizochytrium sp. ABC101. Renewable Energy, 153, 580-587. https://doi.org/10.1016/j.renene.2020.02.047
8. Khozin-Goldberg, , & Cohen, Z. (2006). The effect of phosphate starvation on the lipid and fatty acid composition of the fresh water eustigmatophyte Monodus subterraneus. Phytochemistry, 67(7), 696-701. https://doi.org/10.1016/j. phytochem.2006.01.010
9. Lichtenthaler, K. (1987). Chlorophylls and carotenoids: pigments of photosynthetic biomembranes. pp 350-382. Methods in enzymology, Elsevier. https://doi.org/10.1016/0076-6879(87)48036-1
10. Liu,, Yuan, C., Hu G., & Li, F. (2012). Effects of light intensity on the growth and lipid accumulation of microalga Scenedesmus sp. 11-1 under nitrogen limitation. Applied Biochemistry and Biotechnology, 166(8), 2127-2137. https://doi.org/ 10.1007/s12010-012-9639-2
11. Lv, , Wang, Q.-e., Wang, S., Qi, B., He, J., & Jia, S. (2019). Enhancing biomass production of Dunaliella salina via optimized combinational application of phytohormones. Aquaculture, 503, 146-155.
12. Maswanna, , & Maneeruttanarungroj, C. (2022). Identification of major carotenoids from green alga Tetraspora sp. CU2551: partial purification and characterization of lutein, canthaxanthin, neochrome, and β-carotene. World Journal of Microbiology and Biotechnology, 38(8), 1-13. https://doi.org/10.1007/s11274-022-03320-6
13. Mc Gee, D., Archer, L., Fleming, G.T., Gillespie, E., & Touzet, N. (2020). The effect of nutrient and phytohormone supplementation on the growth, pigment yields and biochemical composition of newly isolated microalgae. Process Biochemistry, 92, 61-68. https://doi.org/10.1016/j.procbio.2020.03.001
14. Montes-González, , González-Silvera, A., Valenzuela-Espinoza, E., Santamaría-del-Ángel, E., & López-Calderón, J. (2021). Effect of light intensity and nutrient concentration on growth and pigments of the green microalga Tetraselmis suecica. Latin American Journal of Aquatic Research, 49(3), 431-441.
15. Mujtaba, , Choi, W., Lee, C.-G., & Lee, K. (2012). Lipid production by Chlorella vulgaris after a shift from nutrient-rich to nitrogen starvation conditions. Bioresource Technology, 123, 279-283. https://doi.org/10.1016/j.biortech.2012. 07.057
16. Nwoba, G., Ogbonna, C.N., Ishika, T., & Vadiveloo, A. (2020). Microalgal pigments: a source of natural food colors. Microalgae Biotechnology for Food, Health and High Value Products, 81-123. https://doi.org/10.1007/978-981-15-0169-2_3
17. Pal, , Khozin-Goldberg, I., Cohen, Z., & Boussiba, S. (2011). The effect of light, salinity, and nitrogen availability on lipid production by Nannochloropsis sp. Applied Microbiology and Biotechnology, 90(4), 1429-1441. https://doi.org/ 10.1007/s00253-011-3170-1
18. Pancha, , Chokshi, K., George, B., Ghosh, T., Paliwal, C., Maurya, R., & Mishra, S. (2014). Nitrogen stress triggered biochemical and morphological changes in the microalgae Scenedesmus sp. CCNM 1077. Bioresource Technology, 156, 146-154. https://doi.org/10.1016/j.biortech.2014.01.025
19. Paniagua-Michel, (2015). Microalgal nutraceuticals. pp 255-267. Handbook of marine microalgae, Elsevier. México. https://doi.org/10.1016/B978-0-12-800776-1.000169
20. Park, -K., Yoo, G., Moon, M., Kim, C.W., Choi, Y.-E., & Yang, J.-W. (2013). Phytohormone supplementation significantly increases growth of Chlamydomonas reinhardtii cultivated for biodiesel production. Applied Biochemistry and Biotechnology, 171(5), 1128-1142. https://doi.org/10.1007/s 12010-013-0386-9
21. Piotrowska-Niczyporuk, , & Bajguz, A. (2014). The effect of natural and synthetic auxins on the growth, metabolite content and antioxidant response of green alga Chlorella vulgaris (Trebouxiophyceae). Plant Growth Regulation, 73(1), 57-66. https://doi.org/10.1007/s10725-013-9867-7
22. Piotrowska-Niczyporuk, , Bajguz, A., Zambrzycka-Szelewa, E., & Bralska, M. (2018). Exogenously applied auxins and cytokinins ameliorate lead toxicity by inducing antioxidant defence system in green alga Acutodesmus obliquus. Plant Physiology and Biochemistry, 132, 535-546. https://doi.org/10.1016/j.plaphy. 2018.09.038
23. Rani, , & Maróti, G. (2021). Assessment of nitrate removal capacity of two selected eukaryotic green microalgae. Cells, 10(9), 2490. https://doi. org/10.3390/cells10092490
24. Ruangsomboon, (2012). Effect of light, nutrient, cultivation time and salinity on lipid production of newly isolated strain of the green microalga, Botryococcus braunii KMITL 2. Bioresource Technology, 109, 261-265. https://doi.org/10.1016/j.biortech.2011.07.025
25. Sathasivam,, & Ki, J.-S. (2018). A review of the biological activities of microalgal carotenoids and their potential use in healthcare and cosmetic industries. Marine Drugs, 16(1), 26. https://doi.org/10.3390/md16010026
26. Shrestha, , Dandinpet, K.K., & Schneegurt, M.A. (2020). Effects of nitrogen and phosphorus limitation on lipid accumulation by Chlorella kessleri str. UTEX 263 grown in darkness. Journal of Applied Phycology, 32(5), 2795-2805. https://doi.org/10.1007/s10811-020-02144-x
27. Shu, H., Tsai, C.C., Liao, W.H., Chen, K.Y., & Huang, H.C. (2012). Effects of light quality on the accumulation of oil in a mixed culture of Chlorella sp. and Saccharomyces cerevisiae. Journal of Chemical Technology & Biotechnology, 87(5), 601-607. https://doi.org/10.1002/jctb.2750
28. Simionato, , Basso, S., Giacometti, G.M., & Morosinotto, T. (2013). Optimization of light use efficiency for biofuel production in algae. Biophysical Chemistry, 182, 71-78. https://doi.org/10.1016/j.bpc.2013.06.017
29. Sirisuk, , Ra, C.-H., Jeong, G.-T., & Kim, S.-K. (2018). Effects of wavelength mixing ratio and photoperiod on microalgal biomass and lipid production in a two-phase culture system using LED illumination. Bioresource Technology, 253, 175-181. https://doi.org/10.1016/j.biortech.2018.01.020
30. Udayan, , Pandey, A.K., Sirohi, R., Sreekumar, N., Sang, B.-I., Sim, S.J., Kim, S.H., & Pandey, A. (2022). Production of microalgae with high lipid content and their potential as sources of nutraceuticals. Phytochemistry Reviews, 1-28. https://doi.org/10.1007/s11101-021-09784-y
31. Venkatesan, , Swamy, M.S., Jayavel, D., Senthil, C., & Bhaskar, S. (2013). Effects of nitrate and phosphate on total lipid content and pigment production in Botryococcus braunii Kutzing KM-104. Journal of Applied Phycology, 23(6): 1031-1037. https://doi.org/10.1007/s10811-010-9636-1
32. Zarrinmehr, J., Farhadian, O., Heyrati, F.P., Keramat, J., Koutra, E., Kornaros, M., & Daneshvar, E. (2020). Effect of nitrogen concentration on the growth rate and biochemical composition of the microalga, Isochrysis galbana. Journal of Aquatic Research, 46(2), 153-158. https://doi.org/10.1016/j.ejar.2019.11.003