Introduction
In recent years, increasing consumer awareness of the dangers of consuming high-fat products, sensitivity to proper nutritional patterns and the impact of health factors has increased consumer demand for low-fat or free-fat foods. Scientific researchers have provided a great quantity of evidence between the consumption of high-fat products and the development of diseases such as obesity, hardening of the arteries, chronic hypertension, etc. Fat removal is not an easy task because fat, in addition to nutritional aspects, affect rheological and sensory properties such as mouth feel and texture properties of the final product. Using alternative materials that can be completely or partially replaced fat in the formulation of low-fat products by imitating the properties of fat is great important. Unlike fat, which its high consumption causes many problems; fiber can play a vital role in many of the nutritional, functional, and sensory properties of food products, Some types of fiber act as fat substitutes, while producing less energy, provide a large effect of fat function properties. Increasing consumption of easy-cook meat products such as sausages induced replacement the fat content in the formulation of these products, by fat substitutes such as maltodextrin. The aim of this study was to evaluate the chemical and sensory properties of low fat German sausages produced by maltodextrin.
Materials and Methods
In this study, 0, 6, 12, and 18% of fat was replaced by maltodextrin in the formulation of German sausage. The chemical and sensory properties were then investigated. Chemical properties including moisture, protein, ash, and fat were accomplished according to the ISIRI standard. Evaluation of sensory properties was done by 5-point hedonic method according to Click et al. (2006). Data analysis was performed using SPSS software in a completely randomized design with a 95% confidence level.
Results and Discussion
The results showed that with increasing the level of maltodextrin, the amount of moisture, ash, and starch of sausage samples increased significantly. As the concentration of maltodextrin increased, the protein content of the samples decreased. The highest protein content observed in the control sample and the sample contained 6% maltodextrin and in contrary, the lowest protein content was in the sample containing 18% maltodextrin and there was no statistically significant difference between the test samples (p>0.05). Changes in maltodextrin concentrations had a significant effect on the fat content of sausage samples so that with increasing the concentration of maltodextrin in the sausage formulation, the fat content of the samples decreased (p≤0.05). Also, with increasing the percentage of maltodextrin replacement in German sausage samples, the cooking yield decreased significantly (p≤0.05). In the evaluation of sensory properties, it was found that the use of maltodextrin reduced the score in all parameters studied so that the lowest score in terms of color, texture, flavor, and total acceptance of sausage samples was related to sample with 18% maltodextrin replacement.
Conclusion
The vital role of the effect of dietary fiber on improving and managing the health has been proven by researchers for many years. Due to the need to reduce fat in products such as sausages, which considered as a popular meat product and based on the results observed in the present study, it is recommended to use maltodextrin fiber at the level of 6% as a fat substitute in the formulation of German sausages. |
- Alaei, F., Hojjatoleslamy, M., & Hashemi Dehkordi, S.M. (2018). The effect of inulin as a fat substitute on the physicochemical and sensory properties of chicken sausages. Food Science & Nutrition, 6(2), 512-519. https://doi.org/10.1002/fsn3.585
- Alesón-Carbonell, L., Fernández-López, J., Pérez-Álvarez, J.A., & Kuri, V. (2005). Characteristics of beef burger as influenced by various types of lemon albedo. Innovative Food Science & Emerging Technologies, 6(2), 247-255. https://doi.org/10.1016/j.ifset.2005.01.002
- (1983). Official method of analysis of AOAC International. Association of Official Analytical Chemists. Washington, DC, Unites States.
- (1991). Official method of analysis of AOAC International. Association of Official Analytical Chemists. Washington, DC, Unites States.
- (1995). Official method of analysis of AOAC International, 16th edition. Association of Official Analytical Chemists. Washington, DC, Unites States.
- Bowker, B. (2017). Developments in our understanding of water-holding capacity. In Poultry quality evaluation (pp. 77-113). Woodhead Publishing. https://org/10.1016/B978-0-08-100763-1.00004-0
- Carvalho, G., Milani, T., & Trinca, N. (2017). Textured soy protein, collagen and maltodextrin as extenders to improve the physicochemical and sensory properties of beef burger. Food Science and Technology, 37(1), 10-17.https://doi.org/10.1590/1678-457X.31916
- de Souza Paglarini, C., Vidal, V.A.S., Dos Santos, M., Coimbra, L.O., Esmerino, E.A., Cruz, A.G., & Pollonio, M.A.R. (2020). Using dynamic sensory techniques to determine drivers of liking in sodium and fat-reduced Bologna sausage containing functional emulsion gels. Food Research International, 132, 109066. https://doi.org/10.1016/j.foodres.2020.109066
- de Souza Paglarini, C., Vidal, V.A., Ribeiro, W., Badan Ribeiro, A.P., Bernardinelli, O.D., Herrero, A.M., Ruiz-Capillas, C., Sabadini, E., & Rodrigues Pollonio, M.A. (2021). Using inulin‐based emulsion gels as fat substitute in salt reduced Bologna sausage. Journal of the Science of Food and Agriculture, 101(2), 505-517. https://org/10.1002/jsfa.10659
- Hadnadev, M., Hadnadev, T.D., Torbica, A., Dokic, L., Pajin, B., & Krstonosic, V. (2011). Rheological properties of maltodextrin based fat – reduced confectionery spread systems. Procedia Food Science, 1, 62–67. https://org/10.1016/j.profoo.2011.09.011
- Hassan, A., Mona, M., Khalil, M., Rania, E., El Gammal, & El Sherbini, Y.I. (2014). Chemical, physical and biological characteristics of low fat beef burger with maltodextrin. Food and Dairy Sciences, Mansoura University, 5(11), 795–811. https://doi.org/21608/JFDS.2014.53229
- Iranian national standard. (2303). Sausages – Specifications and test methods. Reference method.
- Koksoy, A., & Kilic, M. (2004). Use of hydrocolloids in textural stabilization of a yoghurt drink, ayran. Food Hydrocolloids, 18(4), 593-600. https://doi.org/10.1016/j.foodhyd.2003.10.002
- Lima, T.L.S., da Costa, G.F., da Silva Araújo, Í.B., da Cruz, G.R.B., Ribeiro, N.L., Filho, E.M.B., Dominguez, R., & Lorenzo, J.M. (2021). Pre‐emulsioned linseed oil as animal fat replacement in sheep meat sausages: Microstructure and physicochemical properties.Journal of Food Processing and Preservation, 45(1), e15051. https://doi.org/1111/jfpp.15051
- McArdle, R., & Hamill, R. (2011). Utilisation of hydrocolloids in processed meat systems. In Processed meats (pp. 243-269). Woodhead Publishing. https://doi.org/10.1533/9780857092946.2.243
- Nazari, S. M., Mortazavi, A., Hesari, J., & Tabatabaei Yazdi, F. (2019). Proteolysis and textural properties of low‐fat ultrafiltered Feta cheese as influenced by maltodextrin.International Journal of Dairy Technology, 73(1), 244-254. https://doi.org/1111/1471-0307.12642
- Nazari, S. M., Mortazavi, A., Hesari, J., & Tabatabai Yazdi, F. (2016), The effect of maltodextrin from corn starch on the chemical, sensory and microstructure properties of low-fat refined white cheese, Innovative Food Technologies, 3(11), 85-97. (In Persian)
- Neville, M., Tarrega, A., Hewson, L., & Foster, T. (2017). Consumer‐orientated development of hybrid beef burger and sausage analogues.Food Science & Nutrition, 5(4), 852-864. https://doi.org/10.1002/fsn3.466
- Ozturk-Kerimoglu, B., Urgu-Ozturk, M., Serdaroglu, M., & Koca, N. (2022). Chemical, technological, instrumental, microstructural, oxidative and sensory properties of emulsified sausages formulated with microparticulated whey protein to substitute animal fat. Meat Science, 184, 108672. https://doi.org/10.1016/j.meatsci.2021.108672
- Ragheb, R., & Nobbmann, U. (2020). Multiple scattering effects on intercept, size, polydispersity index, and intensity for parallel (VV) and perpendicular (VH) polarization detection in photon correlation spectroscopy. Scientific Reports, 10(1), 21768. https://doi.org/1038/s41598-020-78872-4
- Shahidi, F., Kuchaki, A., & Baghae, H. (2004). Determination of chemical combinations and physical properties local Iranian seed of water melon, pumpkin, cantaloupe & evaluation of their chemical characteristics oils. Journal of Food Science and Industry Ferdowsi of Mashhad, 20(85).
- Udomrat, S., Ikeda, S., & Gohtani, S. (2011). The effect of tapioca maltodextrins on the stability of oil-in-water emulsions. Starch/Starke, 63, 347–353. https://doi.org/1002/star.201000165
|
